Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 SAMMY'S PIZZA OF MANTENO 		License/Permit #
 MA100
Street Address
30 W SECOND ST
City/State
 MANTENO, IL 		ZIP Code
 60950
No. of Risk Factor/Intervention Violations 3
No. of Repeat Risk Factor/Intervention Violations 0
Date 04/29/2022
Time In 01:45 PM
Time Out 03:45 PM
Permit Holder
MANUA, SCOTT 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible X  

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized X  
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37 X Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39   Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41   Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43   In-use utensils: properly stored    
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47   Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55 X Physical facilities installed, maintained & clean    
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58   Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: SAMMY'S PIZZA OF MANTENO Establishment #: MA100
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: CHLORINE 50-100 Heat: 120-140 °F
CFPM Verification (name, ID#, expiration date):


01/01/1900

01/01/1900

01/01/1900

 

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
/cooler 39.00°F /cooler 40.00°F /cooler 41.00°F
/cooler 43.00°F /cooler 40.00°F /cooler 41.00°F
/cooler 42.00°F /cooler 40.00°F /cooler 37.00°F
/cooler 41.00°F /cooler 34.00°F /cooler 41.00°F
/cooler 39.00°F    

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
10 PF 6-301.11: Each HANDWASHING SINK or group of 2 adjacent HANDWASHING SINKS shall be provided with a supply of hand cleaning liquid, powder, or bar soap.
Observed no soap at hand sink in kitchen. Provide soap at all hand sinks. Employee got soap for hand sink. - COS (Correct By: Apr 29, 2022)
10 C 6-301.14: A sign or poster that notifies FOOD EMPLOYEES to wash their hands shall be provided at all HANDWASHING SINKS used by FOOD EMPLOYEES and shall be clearly visible to FOOD EMPLOYEES.
Observed there was no hand washing signs at hand sink in bar or in main kitchen. Provide a hand washing sign at all hand sinks. - (Correct By: Apr 29, 2022)
16 P 4-602.11 (A) (1): (A) EQUIPMENT FOOD-CONTACT SURFACES and UTENSILS shall be cleaned:  (1) Except as specified in ¶ (B) of this section, before each use with a different type of raw animal FOOD such as beef, FISH, lamb, pork, or POULTRY. (B) Subparagraph (A)(1) of this section does not apply if the FOOD-CONTACT SURFACE or UTENSIL is in contact with a succession of different types of raw MEAT and POULTRY each requiring a higher cooking temperature as specified under § 3-401.11 than the previous type.
Can opener blade has food debris on it. Clean and maintain before the next inspection. - COS (Correct By: Apr 29, 2022)
37 C 3-302.12: Except for containers holding FOOD that can be readily and unmistakably recognized such as dry pasta, working containers holding FOOD or FOOD ingredients that are removed from their original packages for use in the FOOD ESTABLISHMENT, such as cooking oils, flour, herbs, potato flakes, salt, spices, and sugar shall be identified with the common name of the FOOD.
Observed there is no label on flour located by fryers. Label flour. - (Correct By: Apr 29, 2022)
49 C 4-601.11(C): (C) NonFOOD-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris.
1. The side of the soda pop machine has debris on it in the kitchen. 2. Grill hood has grease and dust built up in it. 3. Interior of fryers has grease and debris in them. Clean and maintain before the next inspection. - (Correct By: Apr 29, 2022)
55 C 6-501.12: (A)PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean.(B)Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
1. Floor has debris on it under the salad station. 2. Ceiling in beer walk-in cooler has dust and debris on it. 3. Debris on floor in the back hall way. 4. Ceiling and light shields in kitchen has debris on it. Clean and maintain before the next inspection. - (Correct By: Apr 29, 2022)
Inspection Comments   MAKE SURE THERE IS AT LEAST ONE CFPM/SHIFT.
HACCP Topic: MAKE SURE ALL COLD FOOD IS HELD AT 41 F OR BELOW AND CHECK IT THROUGH OUT THE DAY.
 

Person In Charge

  TINA GERSCH 		 

Date:

  04/29/2022
 

Inspector

  Steven Lamb 		 

Follow-up:  Yes   No   Follow-up Date: